PROSPECTS OF THE METHOD OF DRYING CEREALS WITH FOAM

Yo‘ldoshev R.O

PROSPECTS OF THE METHOD OF DRYING CEREALS WITH FOAM

Yo‘ldoshev R.O

Teacher of Termiz State University of Engineering end Agrotechnologies 288, I. Karimov street, Termiz city

##semicolon## spiked grain##common.commaListSeparator## foam mat drying##common.commaListSeparator## methylcellulose

सार

The current study aims to investigate the feasibility of drying high-quality cereal grains using a special foam drying technique. It was carried out by foaming the spiked grains with the addition of egg white (5, 10 and 15%) and methyl cellulose (0.5%). It was dried at three drying temperatures, i.e., 60, 70 and 80 °C in a tray dryer. The drying study showed that the drying time required for foamed cereal pulp was lower than that of non-foamed pulp at all selected temperatures. Biochemical analysis results showed a significant decrease in ascorbic acid and β-carotene content in grain powder obtained at high temperatures compared to pulp dried at a low temperature of 60 °C. Rehydration ratio and water activity values decreased with increasing temperature, but values for both parameters increased with increasing egg white concentration.

An increase in pH values was observed with increasing temperature as well as with increasing egg white concentration. From this study on drying, it was found that grain pulp treated with 10% egg white and 0.5% methyl cellulose and dried at 60 °C retained significantly higher quality characteristics than other foaming and drying methods.

##submission.citations##

1. Earle R L; Earle M D. 1983. Unit operations in food processing. NZIFST (Inc.). New Zealand. Left. 7.

2. Fenemma O R. 1975. Principles of Food Science. Marcel Dekker Inc. New York.

3. Hoover M W. 1973. A process for producing dehydrated pumpkin flakes. J. of Food Sci. 38: 96-98.

4. Ida Idayu Binti Muhammad. 2005. Effect of various processing parameters on the quality of papaya fruit tea. Bioprocess engineering department. Research management center. Final report vol 75146.

5. Kaminski W; Kudra T. 2000. Equilibrium moisture relations for foods and bio materials. Drying Technology in Agriculture and Food Science. Science Publishers, Inc. Enfield, NH. pp. 313.

6. Lewicki P. 1998. Some remarks on rehydration of dried foods. J. of Food Engg. 36: 81-87.

7. Maskan M. 2001. Kinetics of color change of kiwifruits during hot air and microwave drying. J. of Food Engg. 48: 169-175.

8. Mir M A; Nath N. 1993. Storage changes in fortified mango bars. Journal of Food Science & Technol. 30: 279-282.

9. Rajkumar P; Kailappan R. 2006. Optimizing the process parameters for Foam Mat Drying of Totapuri Mango Pulp. Madras Agric. J. 93(1-6): 86-98.

10. Ranganna S. 1999. Handbook of analysis and quality control for fruit and vegetable products (II edition). Tata Mc-Graw Hill Publishing Company Limited. New Delhi.

11. Kamolovich, D. R., O‘G‘Li, A. N. U., Yusupovich, A. K., & Eshqobilovich, Q. B. (2024). TUKLI URUG‘LIK CHIGITNI SARALASHNING TAKOMILLASHTIRILGAN TEXNOLOGIYASI. Механика и технология, 2(15), 169-175.

12. Абдихамидов, Н. У. Ў., Джамолов, Р. К., Каршиев, Б. Э., & Абдуллаев, К. Ю. (2024). ОПРЕДЕЛЕНИЕ ОСНОВНЫХ ПАРАМЕТРОВ СОРТИРОВОЧНОГО АГРЕГАТА ВОЛОСАТЫХ СЕМЯН ХЛОПЧАТНИКА МЕТОДОМ МАТЕМАТИЧЕСКОГО ПЛАНИРОВАНИЯ. Universum: технические науки, 4(5 (122)), 39-44.

13. Эшқобилович, Қ. Б. (2023). ПАХТАНИ ҚУРИТИШ ЖАРАЁНИНИ ТОЛА ВА ЧИГИТ НАМЛИГИГА ТАЪСИРИ. Механика и технология, (2 (5) Спецвыпуск), 309-315.

14. Eshqobilovich, Qarshiev Baxtiyor, Gulboev Otabek Abdimurod O‘G‘Li, and Narzullaev Fazliddin Shuhrat O‘G‘Li. "QURITILGAN PAXTANI PNEVMATIK UZATISHDA TOLA VA CHIGIT TEMPERATURALARIGA TA’SIRINI TAHLILI." Механика и технология 1 (8) Спецвыпуск (2024): 226-230.

15. Абдихамидов Н.У., Джамолов Р.К., Қаршиев Б.Э., Абдуллаев К.Ю. Саралаш камерага ўрнатилган чигитни доналовчи тароқ мосламасининг параметрларини аниқлаш. Фан ва технологиялар тараққиёти илмий – техникавий журнал. №1/2024, Бухоро-2024й-285б.

16. Қаршиев БЭ П. A. П., Сайидова М. Ҳ. Пахтани қатламда қуритишнинг аэродинамик режимларини аниқлаш тадқиқоти //Фан ва технологиялар тараққиѐти. Илмий-техникавий ва амалий журнал. Бухоро. ISSN. – С. 2181-8193.

17. Parpiyev A. P. et al. Tozalash jarayonida arrali seksiyalardan ajralib chiqqan chiqindi ulushlarini baholash natijalari taxlili //Oʻzbekiston toʻqimachilik jurnali. ISSN. – 2010. – Т. 6262. – №. 1. – С. 2022.

18. Каршиев Б. Э., Исматов С. С. РАВНОМЕРНОСТЬ СУШКИ КОМПОНЕНТОВ ХЛОПКА-СЫРЦА //Экономика и социум. – 2023. – №. 9 (112). – С. 485-489.

19. Парпиев А. П., Каршиев Б. Э. РАВНОМЕРНОСТЬ СУШКИ КОМПОНЕНТОВ ХЛОПКА-СЫРЦА //Universum: технические науки. – 2022. – №. 9-2 (102). – С. 51-54.

20. Каршиев Б. Э. и др. Пахтани тозалашга тайёрлаш технологиясининг таҳлили //RESULTS OF NATIONAL SCIENTIFIC RESEARCH. – 2022. – Т. 1. – №. 6.

21. Каршиев Б.Э., Парпиев А.П., Хушбаков А.Н. Анализ температуры, влажности волокна и семян в технологических процессах на хлопкоочистительных предприятиях// INTERNATIONAL SCIENTIFIC AND PRACTICAL CONFERENCE: YOUTH, SCIENCE, EDUCATION: TOPICAL ISSUES, ACHIEVEMENTS AND INNOVATIONS, 2022 Prague, Czech. https://doi.org/10.5281/zenodo.7117865.

22. Қаршиев БЭ П. A. П. Пахта ва уни компонентларини қатламда қуритиш тадқиқоти //ЎзМУ хабарлари. Илмий журнал. ISSN. – С. 2181-7324.

23. Қаршиев БЭ П. A. П., Сайидова М. Ҳ. Пахтани қатламда қуритишнинг аэродинамик режимларини аниқлаш тадқиқоти //Фан ва технологиялар тараққиёти. Илмий-техникавий ва амалий журнал. Бухоро. ISSN. – С. 2181-8193.